Hyundai i10 Maintenance and Repair Costs

All costs are approximate and are inclusive of labour and GST.

Engine Compartment

  • Replacement: Clutch Cable ₹1,200

    Required if: Clutch is hard, Clutch pedal is getting stuck, Clutch is not operable etc. (For vehicles with Cable operated Clutch)

  • Replacement: Spark Plugs (4 Nos.) ₹1,420

    Required if: Engine is misfiring/jerking, Backfiring, Poor Engine Performance, Low Pickup, Car not starting, Rough Idling, Car stalling, Engine knocking, Slow Acceleration, Due for replacement etc.

  • Replacement: Coolant ₹1,150

    Required if: Coolant has excess water content, Coolant was leaking and leakage is arrested, Coolant is due for replacement, Coolant is contaminated, Coolant needs flushing etc.

  • Replacement: Radiator Assembly ₹8,050

    Required if: Coolant leakage from Radiator, Radiator is damaged, Sludge deposits inside Radiator etc.

  • Replacement: Radiator Cap ₹540

    Required if: Radiator Cap is damaged/deformed, Coolant is leaking due to stuck Radiator Cap, Coolant Reservoir Tank is overflowing, Engine is Overheating etc.

  • Replacement: Fuel Pump Relay ₹380

    Required if: Engine not starting, Engine stalling/jerking, Fuel pump is not working (No sound of operation from Fuel Pump is heard when Ignition is switched on), Relay is burned etc.

  • AC Refrigerant Recharge ₹2,750

    Required if: AC Refrigerant was leaking and leakage is arrested, any component in Refrigerant Line is replaced (During the process, refrigerant is discharged) etc.

  • Replacement: Battery (Exide) ₹4,450

    Required if: Battery is dead, Battery is not having minimum voltage for Cranking, Cranking is sluggish, Battery is more than 4 years old, Battery has bulge etc.

  • Replacement: Battery (Amaron) ₹3,800

    Required if: Battery is dead, Battery is not having minimum voltage for Cranking, Cranking is sluggish, Battery is more than 4 years old, Battery has bulge etc.

  • Replacement: Air Intake Hose ₹1,600

    Required if: Air Intake Hose is damaged/missing.

  • Replacement: Fuel Filter ₹830

    Required if: Fuel Filter is due for replacement, Fuel Filter is clogged that can cause Engine misfiring, Rough Idling, Delay in starting/Not starting, Vehicle Stalling etc.

  • Replacement: Front Windshield Wiper Washer Pump/Motor ₹2,550

    Required if: Windshield Washer Motor is not spraying washer fluid, Motor operation is slow etc.

  • Replacement: Serpentine/Drive Belt (V-Belt) ₹1,510

    Required if: Drive Belt has damage, squealing from the front, AC & Alternator malfunctioning and Engine Overheating occur together (when Drive Belt breaks) etc.

  • Replacement: Clutch Plate, Clutch Pressure Plate, Clutch Release Bearing ₹8,600

    Required if: Clutch is Hard/Stiff, Clutch is slipping, Clutch is worn out, Noise while pressing Clutch Pedal, Low pickup, Grinding sound when changing gears, Car not moving when gear is engaged etc.

  • Replacement: Transmission Fluid (Gear Oil) ₹1,000

    Required if: Transmission Fluid is due for replacement, Transmision (Gearbox) is leaking Fluid and leakage is arrested, Transmission Fluid is contaminated, Transmission Fluid's properties are lost which can lead to difficulty in shifting gears, Gears slippage, Noise from Transmission etc.

  • Replacement: Right side Driveshaft ₹4,960

    Required if: Rattling/Clunking/Humming Noise from Driveshaft, Noise while making a turn, Vibration/Shuddering while accelerating. Driveshaft nut is rusted etc.

  • Replacement: AC Compressor Belt ₹850

    Required if: AC Compressor Belt is damaged/cracked/brittle, Squealing from the front, AC Compressor Belt is broken and AC is not working etc.

  • Replacement: Front both Tie Rod Ends (Outer Tie Rod Ends) ₹2,600

    Required if: Suspension Noise from Tie Rod Ends, Tie Rod Ends are damaged, Excess play from Tie Rod Ends, Tie Rod End Boots are damaged and lubrication is lost, Uneven Tyre wear, Vague & Loose Steering Wheel, Vibration from Steering etc.

Exterior

  • Replacement: Front both Wiper Blades ₹960

    Required if: Wiper Blades are not wiping properly, Wiper Blades are damaged, Wiper Blades are hardened.

  • Replacement: Parking Light Bulb (1 No.) ₹60

    Required if: Parking Light Bulb is not working/is blown.

  • Replacement: Radio Antenna ₹2,600

    Required if: Radio Antenna is damaged.

  • Replacement: Radio Antenna Holder (Base) ₹1,200

    Required if: Radio Antenna Holder (Antenna Base) is damaged.

  • Replacement: Reverse Light Bulb (1 No.) ₹95

    Required if: Reverse Light Bulb is not working/is blown.

  • Number Plate (License Plate) Bulb (2 No.s) ₹95

    Required if: Number Plate (License Plate) Bulb is not working/is blown.

  • Replacement: Valve Cover (Valve Door) Gasket including Sealant ₹1,770

    Required if: Valve Door (Valve Cover) is leaking around edges.

  • Replacement: Front Fog Lamp Bulb (1 No.) ₹285

    Required if: Fog Lamp Bulb is not working/is blown.

  • Replacement: Mud Flaps (4 Nos.) ₹1,200

    Required if: Mud Flaps are damaged/missing.

  • Replacement: Front Windshield Glass and Sealant ₹8,300

    Required if: Front Windshield is damaged/broken, Front Windshield has excess scratches which affects night visibility.

  • Replacement: Brake Lamp Bulb (1 No.) ₹90

    Required if: Brake Lamp Bulb is not working/is blown.

  • Replacement: Left side Headlamp Assembly ₹4,050

    Required if: Headlamp Assembly is damaged/broken, Headlamp Assembly is faded/hazy.

  • Replacement: Front Right side Wheel Arch ₹890

    Required if: Wheel Arch is damaged/missing.

Interior

  • Replacement: Gear Shift Lever Cover ₹1,150

    Required if: Gear Shift Lever Cover is damaged.

  • Replacement: Headlamp-Turn Signal Indicator Combination Switch Assembly ₹1,720

    Required if: Headlamps or/and Turn Signal Indicators are not turning on, Turn Signal Indicators are not auto-cancelling etc.

  • Replacement: Brake Light Switch ₹1,400

    Required if: Brake Lights not working, Brake Lights staying on, Vehicle not starting (for specific models that require Brake Pedal to be pressed for starting), Cruise Control malfunctioning (if equipped), Gear Selector not moving out of Park Mode (Automatic) etc.

  • Replacement: Cabin Roof Light Bulb ₹150

    Required if: Cabin Roof Light Bulb is not working/is blown.

  • Replacement: Clutch Pedal Bush ₹295

    Required if: Clutch Pedal Bush is damaged/missing, Noise from Clutch Pedal etc.

  • Replacement: Front Right Door Inner Handle ₹1,300

    Required if: Inner Door Handle is hard to operate, Inner Door Handle is loose to operate, Door is not opening from Inner Handle.

  • Replacement: Electric Power Steering (EPS) Motor ₹7,400

    Required if: Steering is hard to operate, Noise from Electric Power Steering (EPS) Motor while steering is turned, EPS Malfunction Warning Light is glowing.

  • Replacement: Front left Power Window Switch ₹770

    Required if: Power Window is not working from Individual Switch but working from Master Switch, Individual Power Window Switch is damaged etc.

  • Replacement: Brake Pedal Grommet (Stopper Bush) ₹240

    Required if: Brake Light glowing continuously, Grommet (Stopper Bush) is damaged/missing, Noise while Brake Pedal is pressed etc.

Underbody

  • Replacement: Rear both Brake Wheel Cylinders ₹2,950

    Required if: Wheel Cylinder is leaking, Wheel Cylinder is jammed/stuck, Poor Braking Response, Brake feels spongy etc.

  • Replacement: Brake Fluid & Brake Bleeding ₹750

    Required if: Brake Fluid is due for replacement, Brake Fluid is contaminated, Brake Fluid has moisture content, Ineffective Braking etc.

  • Replacement: Silencer (Exhaust Muffler) Assembly ₹9,510

    Required if: Silencer has damage which can cause excess exhaust noise, banging or knocking noises, excess exhaust smell etc.

  • Replacement: Silencer (Exhaust Muffler) Assembly [Center Piece] ₹5,970

    Required if: Silencer has damage which can cause excess exhaust noise, banging or knocking noises, excess exhaust smell etc.

  • Replacement: Silencer (Exhaust Muffler) Assembly [Front Piece] ₹5,900

    Required if: Silencer has damage which can cause excess exhaust noise, banging or knocking noises, excess exhaust smell etc.

  • Replacement: Wheel Stud and Nut (1 Set) ₹710

    Required if: Wheel Stud is damaged/worn out.

  • Replacement: Tyres (Bridgestone) with Valves - 4 Nos. ₹20,300

    Required if: Tyres are worn out, Tyres are damaged, Tyres are hardened, Tyres have cracks, Tyres are too old, Tyre has bulge etc.

  • Replacement: Front both Lower Arms with Ball Joints ₹4,250

    Required if: Lower Arms are damaged, Lower Arm Bushes are damaged/cracked, Lower Arm Ball Joint has excess play, Lower Arm Ball Joint Boot is damaged etc. which can cause Suspension noise from Front Lower Arms, uneven tyre wear, Steering wander etc.

  • Replacement: Front both Shock Absorbers ₹4,425

    Required if: Vehicle has bouncy ride, stiff ride, abnormal noises from shock absorbers, excess body roll, uneven tyre wear, nose diving while braking, rear squat while accelerating, shock absorbers are leaking etc.

  • Replacement: Rear both Shock Absorbers ₹4,400

    Required if: Vehicle has bouncy ride, stiff ride, abnormal noises from shock absorbers, excess body roll, uneven tyre wear, nose diving while braking, rear squat while accelerating, shock absorbers are leaking etc.

  • Replacement: Rear both Shock Absorbers Boot/Bush Kit ₹2,250

    Required if: Shock Absorbers Boots/Bushes are damaged/worn-out.

  • Replacement: Front both Shock Absorbers Boot/Bush Kit ₹2,420

    Required if: Shock Absorbers Boots/Bushes are damaged/worn-out.

  • Replacement: Gearbox (Transmission) Mount ₹2,070

    Required if: Gearbox (Transmission) Mount is damaged, is worn-out, has excess play which can cause vibration when engine is on, jerking motions while accelerating and decelerating etc.

  • Replacement: Front both Link Rods ₹2,950

    Required if: Suspension Noise from Link Rods, Link Rods are damaged, Excess play from Link Rods, Link Rods Boots are damaged, etc.

  • Replacement: Rear both Brake Liners ₹2,600

    Required if: Brake Liners are worn out, Brake Liners' thickness reduced lesser than minimum, Brake Liners are cracked, Noise from Brakes etc.

  • Replacement: Right side Drive Shaft Inner Boot (by dismantling Drive Shaft) ₹2,400

    Required if: Driveshaft Boot is damaged.

  • Replacement: Front both Brake Discs ₹3,720

    Required if: Brake Discs have scoring marks, Brakes are noisy/squealing, Brake Shuddering (Vehicle vibrates when brakes are applied), Brakes Discs are worn out (thickness reduced lesser than minimum) etc.

  • Replacement: Front both Brake Pads ₹2,200

    Required if: Brake pads are worn out, Brake Pads thickness reduced lesser than minimum, Squeaking/Squealing/Grinding Noise from Brakes, Brake pads are cracked, Brake Discs are getting replaced etc.

  • Replacement: Rear Brake Drum (1 No.) ₹2,400

    Required if: Brake Drum has scoring marks, Brakes are noisy/squealing, Brake Shuddering (Vehicle vibrates when brakes are applied), Brakes Drum is worn out (thickness reduced lesser than minimum), Parking Brake getting loose etc.

  • Replacement: Steering Rack Assembly ₹10,100

    Required if: Excess play & noise from Steering Rack, Excess play or looseness with Steering Wheel, Steering is stiff, Steering gets stuck due to lubrication loss etc.

  • Replacement: Stabilizer Bar Bushes​ ₹1,180

    Required if: Stabilizer Bushes are worn out, Noise/Squeaking from Stabilizer Bar Bushes, Stabilizer Bar Bushes are damaged, Stabilizer Bar Bushes are brittle etc.

  • Replacement: Front both Strut Mounts (Shock Absorber Mountings) ₹3,000

    Required if: Excess play from Front Strut Mounts, Noise from Front Suspension, Uneven Tyre wear, Vibration while driving etc.

  • Replacement: Front both Brake Caliper Pin Kit ₹1,770

    Required if: Caliper Pins are worn out, Noise from Caliper Pins, Caliper Pins have excess play etc.

  • Replacement: Rear Wheel Bearing (in Hub Assembly) - 1 No. ₹4,720

    Required if: Noise from Wheel Bearing (Humming/Rumbling noise that increases and decreases with vehicle speed), Excess play in Wheel Bearing, ABS [Magnetic] Reluctor Ring (if equipped) is damaged causing ABS Malfunction etc.

Boot

  • Replacement: Tailgate Struts (Dicky Shocks) - 2 Nos. ₹1,600

    Required if: Tailgate Struts (Dicky Shocks) not holding the Tailgate, Noise from Tailgate Struts (Dicky Shocks) etc.

  • Replacement: Rear Wiper Blade ₹710

    Required if: Wiper Blade is not wiping properly, Wiper Blade is damaged, Wiper Blade is hardened.