Hyundai i20 Maintenance and Repair Costs

All costs are approximate and are inclusive of labour and GST.

Engine Compartment

  • Replacement: Serpentine/Drive Belt (V-Belt) [Diesel] ₹2,400

    Required if: Drive Belt has damage, squealing from the front, AC & Alternator malfunctioning and Engine Overheating occur together (when Drive Belt breaks) etc.

  • Replacement: Serpentine/Drive Belt (V-Belt) [Petrol] ₹2,200

    Required if: Drive Belt has damage, squealing from the front, AC & Alternator malfunctioning and Engine Overheating occur together (when Drive Belt breaks) etc.

  • Replacement: Spark Plugs (4 Nos.) ₹1,600

    Required if: Engine is misfiring/jerking, Backfiring, Poor Engine Performance, Low Pickup, Car not starting, Rough Idling, Car stalling, Engine knocking, Slow Acceleration, Due for replacement etc.

  • Replacement: Clutch Plate, Clutch Pressure Plate & Release Bearing (Diesel) ₹13,000

    Required if: Clutch is Hard/Stiff, Clutch is slipping, Clutch is worn out, Noise while pressing Clutch Pedal, Low pickup, Grinding sound when changing gears, Car not moving when gear is engaged etc.

  • Replacement: Clutch Master Cylinder and Slave Cylinder (Diesel) ₹12,000

    Required if: Clutch is very Hard/Stiff or Soft, Noise while pressing Clutch Pedal, Clutch Pedal feels spongy, Clutch Pedal getting stuck, Clutch Fluid getting reduced (due to leakage from Master Cylinder/Slave Cylinder).

  • Replacement: Idler Pulley and Bearing (Diesel) ₹4,150

    Required if: Idler Pulley is damaged, Noise from Idler, Excess play from Idler etc.

  • Replacement: Rear End (Crankshaft) Oil Seal by dismantling Gearbox Housing (Diesel) ₹5,300

    Required if: Rear End (Crankshaft) Oil Seal is leaking.

  • Replacement: Reverse Light Switch ₹2,150

    Required if: Reverse Lights not working when Reverse gear is engaged.

  • Replacement: Clutch Release Bearing (Diesel) ₹2,050

    Required if: Noise from Release Bearing while pressing and releasing Clutch Pedal, Gears not shifting properly, Leakage from Release Bearing (Hydraulic), Vibration while pressing and releasing Clutch Pedal, Clutch Assembly is getting replaced etc.

  • Replacement: Fuel Filter (Diesel) ₹2,700

    Required if: Fuel Filter is due for replacement, Fuel Filter is clogged that can cause Engine misfiring, Rough Idling, Delay in starting/Not starting, Vehicle Stalling etc.

  • Replacement: Glow Plugs (4 Nos.) ₹6,400

    Required if: Delayed Starting especially in Cold Climate Condition, White Smoke from Exhaust before optimum temperature is attained in Engine etc.

  • Replacement: AC Compressor ₹17,500

    Required if: AC not working, No Cooling from AC, AC Compressor not working etc.

  • AC Refrigerant Recharge ₹2,750

    Required if: AC Refrigerant was leaking and leakage is arrested, any component in Refrigerant Line is replaced (During the process, refrigerant is discharged) etc.

  • Replacement: Electric Power Steering (EPS) Motor ₹7,010

    Required if: Steering is hard to operate, Noise from Electric Power Steering (EPS) Motor while steering is turned, EPS Malfunction Warning Light is glowing.

  • Replacement: Clutch Master Cylinder and Slave Cylinder (Petrol) ₹12,000

    Required if: Clutch is very Hard/Stiff or Soft, Noise while pressing Clutch Pedal, Clutch Pedal feels spongy, Clutch Pedal getting stuck, Clutch Fluid getting reduced (due to leakage from Master Cylinder/Slave Cylinder).

  • Replacement: Battery - Exide (Petrol) ₹4,500

    Required if: Battery is dead, Battery is not having minimum voltage for Cranking, Cranking is sluggish, Battery is more than 4 years old, Battery has bulge etc.

  • Replacement: Coolant ₹1,660

    Required if: Coolant has excess water content, Coolant was leaking and leakage is arrested, Coolant is due for replacement, Coolant is contaminated, Coolant needs flushing etc.

  • Replacement: Radiator Assembly ₹6,610

    Required if: Coolant leakage from Radiator, Radiator is damaged, Sludge deposits inside Radiator etc.

  • Replacement: AC Compressor Control Valve ₹3,130

    Required if: AC not working, AC has low cooling, AC is not cooling, AC is not cooling intermittently etc.

  • Replacement: Spark Plug Cord Wires (Ignition Cables) [Set of 4] ₹2,250

    Required if: Spark Plug Cord Wires (Ignition Cables) are damaged which can cause Engine misfiring/jerking, Poor Engine Performance, Low Pickup, Car not starting, Rough Idling, Car stalling, Engine knocking, Check Engine Light/Malfunction Indicator Lamp (MIL) Glowing etc.

  • Replacement: Thermostat Elbow with Hose & Clamps ₹2,360

    Required if: Thermostat Elbow is damaged/leaking/cracked/brittle etc.

Exterior

  • Replacement: Front both Wiper Blades ₹780

    Required if: Wiper Blades are not wiping properly, Wiper Blades are damaged, Wiper Blades are hardened.

  • Replacement: Number Plate (License Plate) Bulb - 2 Nos. ₹120

    Required if: Number Plate (License Plate) Bulb is not working/is blown.

  • Replacement: Brake High Mount Stop Lamp Bulbs (3 Nos.) ₹250

    Required if: Brake High Mount Stop Lamp Bulb is not working/is blown.

  • Replacement: Right side ORVM (Outside Rear View Mirror) Assembly ₹5,850

    Required if: ORVM (Outside Rear View Mirror) Assembly is damaged/missing, Mirror Adjustment/Folding Actuators faulty (if applicable) etc.

  • Replacement: Parking Light Bulb​ (1 No.) ₹95

    Required if: Parking Light Bulb is not working/is blown.​

  • Replacement: Headlamp Bulb ₹250

    Required if: Headlamp Bulb is not working/is blown.

  • Replacement: Rear Wiper Arm with Wiper Blade ₹1,100

    Required if: Rear Wiper Arm is damaged/missing, Wiper Blade is not wiping properly, Wiper Blade is damaged, Wiper Blade is hardened.

  • Replacement: Both sides Headlamp Assembly ₹9,680

    Required if: Headlamp Assembly is damaged/broken, Headlamp Assembly is faded/hazy.​

  • Replacement: Left side ORVM Lens (Mirror Plate) ₹780

    Required if: ORVM Lens (Mirror Plate) is broken/damaged/missing.

  • Replacement: Rear Turn Signal Indicator Bulb (1 No.) ₹60

    Required if: Rear Turn Signal Indicator Bulb is not working/is blown.

  • Replacement: Brake Light Bulb (1 No.) ₹100

    Required if: Brake Light Bulb is not working/is blown.

  • Replacement: Front Windshield Glass and Sealant ₹8,300

    Required if: Front Windshield is damaged/broken, Front Windshield has excess scratches.

Interior

  • Replacement: AC Recirculation Mode Flap Actuator ₹2,600

    Required if: AC Recirculation Flap is not actuating when operated.

  • Replacement: Power Window Master Switch ₹2,500

    Required if: Power Windows are not working from Master Switch but working from Individual Switches, Power Window Motor is in working condition but not operating from Switch, Power Window Master Switch is damaged etc.

  • Replacement: Cabin Roof Light Assembly ₹1,750

    Required if: Cabin Roof Light Assembly is damaged/faulty.

  • Replacement: Rear both sides Power Window Switches ₹2,000

    Required if: Power Window is not working from Individual Switch but working from Master Switch, Individual Power Window Switch is damaged etc.

  • Replacement: Brake Pedal Grommet (Stopper Bush) ₹450

    Required if: Brake Light glowing continuously, Grommet (Stopper Bush) is damaged/missing.

  • Replacement: Rear Right Power Window Switch ₹1,300

    Required if: Power Window is not working from Individual Switch but working from Master Switch, Individual Power Window Switch is damaged etc.

  • Replacement: Front Left Power Window Switch ₹1,300

    Required if: Power Window is not working from Individual Switch but working from Master Switch, Individual Power Window Switch is damaged etc.

  • Replacement: Gear Lever Boot ₹1,180

    Required if: Gear Lever Boot is damaged.

  • Replacement: Evaporator Coil Hose 'O' Ring ₹3,720

    Required if: Evaporator Coil Hose 'O' Ring is leaking.

  • Replacement: Front Left side Door Latch Assembly ₹3,955

    Required if: Door not closing, Door not opening, Door has to be slammed hard to close, Latch is damaged etc.

  • Replacement: Front Left Door Inner Handle ₹1,065

    Required if: Inner Door Handle is hard to operate, Inner Door Handle is loose to operate, Door is not opening from Inner Handle.

  • Replacement: Cabin Roof Light Bulb ₹90

    Required if: Cabin Roof Light Bulb is not working/is blown.

Underbody

  • Replacement: Engine Bottom Guard Shield (Underbody Splash Guard) ₹1,700

    Required if: Engine Bottom Guard Shield (Underbody Splash Guard) is damaged/missing.

  • Replacement: Rear Wheel Bearing in Hub Assembly with ABS Wheel Speed Sensor (1 No.) ₹4,850

    Required if: Noise from Wheel Bearing (Humming/Rumbling noise that increases and decreases with vehicle speed), Vehicle vibration, Excess play in Wheel Bearing, ABS Malfunction Light Glowing, ABS & Traction Control Malfunctioning, Brake Pedal pulsating due to false speed data etc.

  • Replacement: Front both Brake Pads ₹2,850

    Required if: Brake pads are worn out, Brake Pads thickness reduced lesser than minimum, Squeaking/Squealing/Grinding Noise from Brakes, Brake pads are cracked, Brake Discs are getting replaced etc.

  • Replacement: Front both Brake Caliper Pin Kit ₹2,065

    Required if: Caliper Pins are worn out, Noise from Caliper Pins, Caliper Pins have excess play etc.

  • Replacement: Rear both Brake Pads ₹2,600

    Required if: Brake pads are worn out, Brake Pads thickness reduced lesser than minimum, Squeaking/Squealing/Grinding Noise from Brakes, Brake pads are cracked, Brake Discs are getting replaced etc.

  • Replacement: Rear both Brake Caliper Pin Kit ₹1,700

    Required if: Caliper Pins are worn out, Noise from Caliper Pins, Caliper Pins have excess play etc.

  • Replacement: Front Right Side Wheel Bearing (Including Lathe Charges) ₹2,900

    Required if: Noise from Wheel Bearing (Humming/Rumbling noise that increases and decreases with vehicle speed), Steering vibration, Vehicle pulls to one side, Vague Steering Wheel, Excess play in Wheel Bearing etc.

  • Replacement: Rear both Brake Liners ₹2,600

    Required if: Brake Liners are worn out, Brake Liners' thickness reduced lesser than minimum, Brake Liners are cracked, Noise from Brakes etc.

  • Replacement: Rear both Shock Absorber Stopper Bushes (Bump Stop) ₹2,350

    Required if: Shock Absorber Stopper Bushes are damaged/cracked/missing.

  • Replacement: Tyres (Apollo) with Valves - 4 Nos. ₹20,700

    Required if: Tyres are worn out, Tyres are damaged, Tyres are hardened, Tyres have cracks, Tyres are too old, Tyre has bulge etc.

  • Replacement: Rear both Brake Wheel Cylinders ₹2,400

    Required if: Wheel Cylinder is leaking, Wheel Cylinder is jammed/stuck, Poor Braking Response, Brake feels spongy etc.

  • Replacement: Brake Fluid & Brake Bleeding ₹950

    Required if: Brake Fluid is due for replacement, Brake Fluid is contaminated, Brake Fluid has moisture content, Ineffective Braking etc.

  • Replacement: Wheel Stud and Nut (1 Set) ₹890

    Required if: Wheel Stud is damaged.

  • Replacement: Front both Shock Absorbers ₹6,000

    Required if: Vehicle has bouncy ride, stiff ride, abnormal noises from shock absorbers, excess body roll, uneven tyre wear, nose diving while braking, rear squat while accelerating, shock absorbers are leaking etc.​

  • Replacement: Front both Strut Mounts (Shock Absorber Mountings) ₹2,200

    Required if: Excess play from Front Strut Mounts, Noise from Front Suspension, Uneven Tyre wear, Vibration while driving etc.

  • Replacement: Front both Shock Absorber Boot/Bush Kit ₹1,600

    Required if: Shock Absorber Boots/Bushes are damaged/worn-out.

  • Replacement: Steering Rack Assembly ₹13,000

    Required if: Excess play & noise from Steering Rack, Excess play or looseness with Steering Wheel, Steering is stiff, Steering gets stuck due to lubrication loss etc.

  • Replacement: Rear both Shock Absorbers ₹5,000

    Required if: Vehicle has bouncy ride, stiff ride, abnormal noises from shock absorbers, excess body roll, uneven tyre wear, nose diving while braking, rear squat while accelerating, shock absorbers are leaking etc.​

  • Replacement: Rear both Shock Absorber Boot/Bush Kit ₹2,200

    Required if: Shock Absorber Boots/Bushes are damaged/worn-out.

  • Replacement: Front Left side Fender Liner ₹950

    Required if: Fender Liner is damaged or missing.

  • Replacement: Front both Link Rods ₹3,010

    Required if: Suspension Noise from Link Rods, Link Rods are damaged, Excess play from Link Rods, Link Rods Boots are damaged, etc.

  • Replacement: Front both Lower Arms ₹4,720

    Required if: Lower Arms are damaged, Lower Arm Bushes are damaged/cracked, Lower Arm Ball Joint has excess play, Lower Arm Ball Joint Boot is damaged etc. which can cause Suspension noise from Front Lower Arms, uneven tyre wear, Steering wander etc.

Boot

  • Replacement: Tailgate Struts (Dicky Shocks) - 2 Nos. ₹1,600

    Required if: Tailgate Struts (Dicky Shocks) not holding the Tailgate, Noise from Tailgate Struts (Dicky Shocks) etc.

  • Replacement: Boot Switch ₹2,600

    Required if: Boot Switch is damaged, Boot is not opening from Switch.

  • Replacement: Wheel Spanner ₹710

    Required if: Wheel Spanner is damaged/missing.

  • Replacement: Jack Handle Lever ₹590

    Required if: Jack Handle Lever is damaged/missing.

  • Replacement: Dicky/Boot Lid's Trim/Pad ₹2,720

    Required if: Dicky/Boot Lid's Trim/Pad is damaged/missing.