Volkswagen Vento Maintenance and Repair Costs

All costs are approximate and are inclusive of labour and GST.

Engine Compartment

  • Replacement: Battery - Exide (Petrol 1.2 TSI) ₹5,200

    Required if: Battery is dead, Battery is not having minimum voltage for Cranking, Cranking is sluggish, Battery is more than 4 years old, Battery has bulge etc.

  • Replacement: Battery - Amaron (Petrol 1.2 TSI) ₹5,000

    Required if: Battery is dead, Battery is not having minimum voltage for Cranking, Cranking is sluggish, Battery is more than 4 years old, Battery has bulge etc.

  • Replacement: Battery - Amaron (Diesel) ₹6,300

    Required if: Battery is dead, Battery is not having minimum voltage for Cranking, Cranking is sluggish, Battery is more than 4 years old, Battery has bulge etc.

  • Replacement: Camshaft Position Sensor (Petrol 1.6 MPI) ₹3,070

    Required if: Engine not starting/delayed starting, Engine Stalling, Engine RPM Fluctuation, Check Engine Light Glowing etc.

  • Replacement: Radiator Support Panel ₹8,085

    Required if: Radiator Support Panel is damaged.

  • Replacement: Ignition Coil (2 Nos.) ₹8,090

    Required if: Engine Misfiring, Engine Vibration, Engine Jerking, Engine Stalling, Engine Power Loss, Engine delayed starting, Check Engine Warning Light Glowing etc.

  • Replacement: Coolant Reservoir Tank ₹2,950

    Required if: Coolant Reservoir Tank is leaking/damaged.

  • Replacement: Timing Kit - Timing Chain, Chain Guide, Tensioner and Chain Sprocket (Petrol 1.2 TSI) ₹20,100

    Required if: Timing Kit Replacement is due, Rattling Noise from Timing Case side when Engine is running, Timing Chain is broken (Consequential damage to other Engine Components will also occur in such situation) etc.

  • Replacement: Timing Belt Kit with Water Pump (Diesel) ₹17,700

    Required if: Timing Kit Replacement is due, Crack/damage on Timing Belt, Timing Belt is broken (Consequential damage to other Engine Components will also occur in such situation) etc.

  • Replacement: Main Shaft (Crankshaft) Oil Seal (Petrol 1.2 TSI) ₹2,070

    Required if: Main Shaft (Crankshaft) Oil Seal is leaking, Timing Kit is getting replaced.

  • Replacement: Hood Insulator ₹3,500

    Required if: Hood Insulator is damaged/missing.

  • Replacement: Fuel Filter (Diesel) ₹3,070

    Required if: Fuel Filter is due for replacement, Fuel Filter is clogged that can cause Engine misfiring, Rough Idling, Delay in starting/Not starting, Vehicle Stalling etc.

  • Replacement: Clutch Plate, Clutch Pressure Plate & Clutch Release Bearing (Diesel) ₹14,750

    Required if: Clutch is Hard/Stiff, Clutch is slipping, Clutch is worn out, Noise while pressing Clutch Pedal, Low pickup, Grinding sound when changing gears, Car not moving when gear is engaged etc.

  • AC Refrigerant Recharge ₹2,750

    Required if: AC Refrigerant was leaking and leakage is arrested, any component in Refrigerant Line is replaced (During the process, refrigerant is discharged) etc.

  • Replacement: Water Pump Assembly (Petrol 1.2 TSI) ₹7,800

    Required if: Coolant is leaking from Water Pump, Noise from Water Pump, Excess play in Water Pump Pulley, Timing Kit is getting replaced etc.

  • Replacement: Water Pump Assembly (Petrol 1.6 MPI) ₹6,500

    Required if: Coolant is leaking from Water Pump, Noise from Water Pump, Excess play in Water Pump Pulley, Timing Kit is getting replaced etc.

  • Replacement: Thermostat Assembly (Diesel) ₹3,500

    Required if: Thermostat is leaking Coolant, Engine Overheating (Thermostat Valve is stuck closed), Engine Overcooling (Thermostat Valve is stuck open) etc.

  • Replacement: Fuel Filter (Petrol) ₹1,770

    Required if: Fuel Filter is due for replacement, Fuel Filter is clogged that can cause Engine misfiring, Rough Idling, Delay in starting/Not starting, Vehicle Stalling etc.

  • Replacement: Radiator Fan Assembly ₹10,650

    Required if: Radiator Fan is not operating which causes Engine overheating and AC malfunction, Radiator Fan is damaged, Radiator Fan has excess play/vibration etc.

  • Replacement: Dual-Mass Flywheel (Diesel 1.5 TDI) ₹21,400

    Required if: Rattling Noise from Flywheel, Clutch is Slipping, Vehicle Vibration etc.

  • Replacement: Transmission Fluid (DSG) ₹4,750

    Required if: Transmission Fluid is due for replacement, Transmision (Gearbox) is leaking Fluid and leakage is arrested, Transmission Fluid is contaminated, Transmission Fluid's properties are lost which can lead to difficulty in shifting gears, Gears slippage, Noise from Transmission etc.

  • Replacement: Flywheel Needle Bearing (Pilot Bearing) ₹2,750

    Required if: Noise from Clutch, Vibration through gear shifting, Stuck Clutch etc.

  • Replacement: Right side Driveshaft Oil Seal (Petrol 1.2 TSI) ₹1,600

    Required if: Driveshaft Oil Seal has leakage.

  • Replacement: Spark Plugs (Iridium) - 4 Nos. ₹2,775

    Required if: Engine is misfiring/jerking, Backfiring, Poor Engine Performance, Low Pickup, Car not starting, Rough Idling, Car stalling, Engine knocking, Slow Acceleration, Due for replacement etc.

  • Replacement: Serpentine/Drive Belt (V-Belt) [Diesel] ₹950

    Required if: Drive Belt has damage, squealing from the front, AC & Alternator malfunctioning and Engine Overheating occur together (when Drive Belt breaks) etc.

  • Replacement: Serpentine/Drive Belt (V-Belt) Tensioner [Diesel] ₹5,550

    Required if: Serpentine/Drive Belt (V-Belt) Tensioner is damaged, Noise from Tensioner etc.

  • Replacement: Intercooler Hose ₹7,100

    Required if: Intercooler Hose has damage which can cause Power Loss, Poor Acceleration, Hissing Sound, Malfunction Indicator Lamp Glowing etc.

  • Replacement: Dual Clutch Assembly by dismantling Transmission Assembly & Transmission Adaptation (Diesel 1.5 TDI) ₹56,050

    Required if: Clutch is slipping, Clutch is worn out, Low pickup, Gears not shifting, Vehicle not moving even when Drive Mode is engaged etc.

  • Replacement: Right side Driveshaft Oil Seal (Petrol 1.6 MPI) ₹1,865

    Required if: Driveshaft Oil Seal has leakage.

  • Replacement: Heater Core Hose ₹2,950

    Required if: Heater Core Hose is damaged/leaking/cracked/brittle.

  • Replacement: AC Compressor ₹17,700

    Required if: AC not working, AC has low cooling, AC is not cooling, AC is not cooling intermittently etc.

  • Replacement: Idler Pulley (Petrol 1.6 MPI) ₹4,210

    Required if: Idler Pulley is damaged, Noise from Idler, Excess play from Idler etc.

  • Replacement: Coolant ₹3,500

    Required if: Coolant has excess water content, Coolant was leaking and leakage is arrested, Coolant is due for replacement, Coolant is contaminated, Coolant needs flushing etc.

  • Replacement: Valve Cover (Valve Door) Gasket [Diesel 1.6 TDI] ₹3,310

    Required if: Valve Cover (Valve Door) is leaking around edges.

  • Replacement: Flywheel (Diesel 1.6 TDI) ₹18,500

    Required if: Flywheel has burnt marks, Burning smell, Clutch Vibration, Difficulty in changing gears, Gears are slipping etc.

  • Replacement: Alternator Assembly (Diesel 1.5 TDI) ₹14,400

    Required if: Vehicle not starting as battery is not getting charged, Electrical malfunctions, Engine stalling, Alternator (Battery) warning light glowing, Heavy Power Steering, Dimming Headlights, Delayed cranking etc.

  • Replacement: Engine Mount / Bedding (Diesel 1.5 TDI) ₹4,425

    Required if: Engine Mount is damaged, is worn-out, has excess play which can cause vibration when engine is on, jerking motions while accelerating and decelerating etc.

  • Replacement: Multi Fuse ₹4,720

    Required if: Multi Fuse is blown.

  • Replacement: Windshield Washer Fluid Tank Cap ₹355

    Required if: Windshield Washer Fluid Tank Cap is damaged/missing.

Exterior

  • Replacement: Front both Wiper Blades ₹770

    Required if: Wiper Blades are not wiping properly, Wiper Blades are damaged, Wiper Blades are hardened.

  • Replacement: Left side Headlamp Assembly ₹9,450

    Required if: Headlamp Assembly is damaged/broken, Headlamp Assembly is faded/hazy.​

  • Replacement: Left side Tail Lamp Assembly ₹3,400

    Required if: Tail Lamp Assembly is damaged.

  • Replacement: Brake Light Bulb (1 No.) ₹120

    Required if: Brake Light Bulb is not working/is blown.

  • Replacement: Parking Light Bulb​ (1 No.) ₹110

    Required if: Parking Light Bulb is not working/is blown.​

  • Replacement: Front Fog Lamp Bulb (1 No.) ₹360

    Required if: Fog Lamp Bulb is not working/is blown.

  • Replacement: Front both Windshield Wiper Washer Nozzles ₹950

    Required if: Windshield Wiper Washer Nozzles are damaged/fully blocked.

  • Replacement: Right side ORVM (Outside Rear View Mirror) Cap & Painting ₹1,620

    Required if: ORVM (Outside Rear View Mirror) Cap is damaged/missing.

  • Replacement: Rear Fog Lamp Bulb (1 No.) ₹120

    Required if: Fog Lamp Bulb is not working/is blown.

  • Replacement: Rear both Shock Absorbers Boot/Bush Kit ₹2,950

    Required if: Shock Absorbers Boots/Bushes are damaged/worn-out.

  • Replacement: Wheel Bolt (1 No.) ₹475

    Required if: Wheel Bolt is missing/damaged.

  • Replacement: Headlamp Bulb (1 No.) ₹535

    Required if: Headlamp Bulb is not working/is blown.

Interior

  • Replacement: Front Left side AC Vent ₹1,660

    Required if: Front left side AC Vent is damaged/missing.

  • Replacement: Center AC Vent Assembly ₹3,660

    Required if: Center AC Vent is damaged/missing.

  • Replacement: Rear AC Vent Assembly ₹1,200

    Required if: Rear AC Vent is damaged/missing.

  • Replacement: AC Evaporator Assembly by dismantling Dashboard ₹6,050

    Required if: AC has no or less cooling as a result of leakage from Evaporator. (Smell of refrigerant noticed in the cabin if Refrigerant hasn't got depleted yet by the leakage).

  • Replacement: Power Window Master Switch ₹4,075

    Required if: Power Windows are not working from Master Switch but working from Individual Switches, Power Window Motor is in working condition but not operating from Switch, Power Window Master Switch is damaged etc.

  • Replacement: Front left side Power Window Switch ₹1,480

    Required if: Power Window is not working from Individual Switch but working from Master Switch, Individual Power Window Switch is damaged etc.

  • Replacement: Rear left side Power Window Switch ₹1,480

    Required if: Power Window is not working from Individual Switch but working from Master Switch, Individual Power Window Switch is damaged etc.

  • Replacement: Front Right side AC Vent ₹1,720

    Required if: Right side AC Vent is damaged/missing.

  • Replacement: AC Flap Positioning Motor (by dismantling Dashboard) ₹4,000

    Required if: Flap Position is not operable, Air not coming through Center AC Vents etc.

  • Replacement: Cabin Roof Light Assembly ₹4,825

    Required if: Cabin Roof Light Assembly is damaged, Cabin Roof Light is not working etc.

  • Replacement: Ignition Switch ₹8,300

    Required if: Vehicle not starting, Vehicle stalling while driving, Electrical Accessories not working, Key getting stuck in lock cylinder etc.

  • Replacement: AC Blower Motor Assembly ₹12,980

    Required if: AC is not working (No airflow from AC vents), AC Blower not working, Noise from AC Blower Motor etc.

Underbody

  • Replacement: Front both Shock Absorbers ₹6,850

    Required if: Vehicle has bouncy ride, stiff ride, abnormal noises from shock absorbers, excess body roll, uneven tyre wear, nose diving while braking, rear squat while accelerating, shock absorbers are leaking etc.​

  • Replacement: Front both Strut Mounts (Shock Absorber Mountings) ₹4,750

    Required if: Excess play from Front Strut Mounts, Noise from Front Suspension, Uneven Tyre wear, Vibration while driving etc.

  • Replacement: Front both Shock Absorber Boot/Bush Kit ₹2,850

    Required if: Shock Absorber Boots/Bushes are damaged/worn-out.

  • Replacement: Front both Lower Arms ₹7,600

    Required if: Lower Arms are damaged, Lower Arm Bushes are damaged/cracked, Lower Arm Ball Joint has excess play, Lower Arm Ball Joint Boot is damaged etc. which can cause Suspension noise from Front Lower Arms, uneven tyre wear, Steering wander etc.

  • Replacement: Rear both Shock Absorber Boot/Bush Kit ₹2,950

    Required if: Shock Absorber Boots/Bushes are damaged/worn-out.

  • Replacement: Steering Rack Assembly ₹14,500

    Required if: Excess play & noise from Steering Rack, Excess play or looseness with Steering Wheel, Steering is stiff, Steering gets stuck due to lubrication loss etc.

  • Replacement: Rear both Brake Wheel Cylinders ₹2,700

    Required if: Wheel Cylinder is leaking, Wheel Cylinder is jammed/stuck, Poor Braking Response, Brake feels spongy etc.

  • Replacement: Brake Fluid & Brake Bleeding ₹800

    Required if: Brake Fluid is due for replacement, Brake Fluid is contaminated, Brake Fluid has moisture content, Ineffective Braking etc.

  • Replacement: Tyres (Bridgestone) with Valves - 2 Nos. ₹12,650

    Required if: Tyres are worn out, Tyres are damaged, Tyres are hardened, Tyres have cracks, Tyres are too old, Tyre has bulge etc.

  • Replacement: Tyre (Goodyear) - 1 No. ₹5,920

    Required if: Tyres are worn out, Tyres are damaged, Tyres are hardened, Tyres have cracks, Tyres are too old, Tyre has bulge etc.

  • Replacement: Front both Brake Discs ₹5,400

    Required if: Brake Discs have scoring marks, Brakes are noisy/squealing, Brake Shuddering (Vehicle vibrates when brakes are applied), Brakes Discs are worn out (thickness reduced lesser than minimum) etc.

  • Replacement: Front both Brake Pads ₹2,950

    Required if: Brake pads are worn out, Brake Pads thickness reduced lesser than minimum, Squeaking/Squealing/Grinding Noise from Brakes, Brake pads are cracked, Brake Discs are getting replaced etc.

  • Replacement: Front both Shock Absorbers (Strut) Bearings and Nuts ₹1,700

    Required if: Noise is occuring while making a turn or passing over rough terrain or bumps, Uneven tyre wear, Bad Wheel Alignment, Shock Absorbers are getting replaced etc.

  • Replacement: Stabilizer Bar Bushes ₹1,480

    Required if: Stabilizer Bushes are worn out, Noise/Squeaking from Stabilizer Bar Bushes, Stabilizer Bar Bushes are damaged, Stabilizer Bar Bushes are brittle etc.

  • Replacement: Front both Link Rods ₹5,750

    Required if: Suspension Noise from Link Rods, Link Rods are damaged, Excess play from Link Rods, Link Rods Boots are damaged, etc.

  • Replacement: Right side Fender Liner ₹2,150

    Required if: Fender Liner is damaged/missing.

  • Replacement: Front Wheel Bearing (1 No.) ₹3,370

    Required if: Noise from Wheel Bearing (Humming/Rumbling noise that increases and decreases with vehicle speed), Steering vibration, Vehicle pulls to one side, Vague Steering Wheel, Excess play in Wheel Bearing, ABS [Magnetic] Reluctor Ring (if equipped) is damaged causing ABS Malfunction etc.

  • Replacement: Front Right side ABS Wheel Speed Sensor ₹ 5,195

    Required if: ABS Malfunction Light Glowing, ABS & Traction Control Malfunctioning, Brake Pedal pulsating due to false speed data etc. ​

  • Replacement: Front Left side ABS Wheel Speed Sensor ₹ 5,195

    Required if: ABS Malfunction Light Glowing, ABS & Traction Control Malfunctioning, Brake Pedal pulsating due to false speed data etc. ​

  • Replacement: Rear both Brake Liners ₹3,550

    Required if: Brake Liners are worn out, Brake Liners' thickness reduced lesser than minimum, Brake Liners are cracked, Noise from Brakes etc.

  • Replacement: Front both Brake Caliper Pin Kit ₹3,450

    Required if: Caliper Pins are worn out, Noise from Caliper Pins, Caliper Pins have excess play etc.

  • Replacement: Front both Link Rods ₹5,725

    Required if: Suspension Noise from Link Rods, Link Rods are damaged, Excess play from Link Rods, Link Rods Boots are damaged, etc.

  • Replacement: Engine Bottom Shield (Splash Guard) ₹2,200

    Required if: Engine Bottom Shield (Splash Guard) is damaged or missing.

Boot

  • Replacement: Dicky/Boot Lid/Tailgate 'VOLKSWAGEN' Monogram ₹770

    Required if: Dicky/Boot Lid/Tailgate Monogram is missing/damaged.